Latest news from Heavy Lift & Project Forwarding International Magazine

Mobile crane survives ‘mighty forces of nature’

A crane supplied by Schmidbauer for the upgrade of the GARS O’Higgins (German Antarctic Receiving Station) research station in Antarctica has completed its test phase.

The transportation of the 24-ton (21.1-tonne) Liebherr LTM 1040 mobile crane to the site was no mean feat.

The crane had to be delivered to the research station on pontoons from the landing site located 2 km away; ships may not approach any closer to the island in order to protect the nearby penguin population.

The crane was dismantled into parts weighing no more than 8 tons (7.3 tonnes) in order to comply with the pontoon’s weight bearing capacity.

Schmidbauer highlighted “the mighty forces of nature” en route. Some of the individual parts of the crane were stored on deck during transportation due to their size and special tarpaulins were used to protect them against the elements.

During the test phase, which began in December 2018, the Schmidbauer team lifted loads with the mobile crane on behalf of a neighbouring Chilean research station.

Schmidbauer explained: “The crane was rendered winter proof immediately after its successful assembly. Since work cannot be carried out over the Antarctic winter with minus temperatures and strong winds, the crane stood in the garage of the neighbouring Chilean station for the next few months where it could be used for occasional lifting work.”

Depending on the weather conditions over the Antarctic summer, the mobile crane will be used for four to six months to move containers and parts of the station before being winter proofed again. This cycle will be repeated two to three times before the upgrade work is completed, Schmidbauer said, adding that the next construction phase is scheduled to start again in November 2019.

The German Aerospace Centre (DLR) has been operating an observation station in Antarctica for almost 30 years. Its living and office containers will be expanded over the next two years, while the upgrade of the technical areas of the station is set for completion by 2020.

www.schmidbauer-gruppe.de

Heavy Lift | News

Big Carl on show at Hinkley thumbnail image

Big Carl on show at Hinkley

September 13 - The giant Sarens SGC 250 ring crane is ready to start construction work at EDF’s Hinkley Point C nuclear power station.
Views: 453
Texas places Konecranes order thumbnail image

Texas places Konecranes order

September 11 - The port of Brownsville, USA, has placed an order with Konecranes for two Gottwald Model 6 mobile harbour cranes.
Views: 479
New brakes for Sleipnir cranes thumbnail image

New brakes for Sleipnir cranes

September 5 - Pintsch Bubenzer has installed a set of Twin Safe TS800 brakes on two 10,000-tonne capacity revolving cranes on board the semi-submersible vessel Sleipnir.
Views: 944

Heavy Lift Across The World

Discover heavy lift and project logistics industry news from around the world by region.